In December 1903, the Wright brothers tested their aircraft in North Carolina. Orville piloted the first powered flight that day, which lasted approximately 12 seconds.
The brothers placed great emphasis on wing control and flight testing. Their achievement involved not only an engine but also techniques for keeping an aircraft stable and controllable.
Adding power
In 1903 the brothers built the powered Wright Flyer, using their preferred material for construction, spruce, a strong and lightweight wood, and Pride of the West muslin for surface coverings. They also designed and carved their own wooden propellers, and had a purpose-built gasoline engine fabricated in their bicycle shop. They thought propeller design would be a simple matter and intended to adapt data from shipbuilding. However, their library research disclosed no established formulae for either marine or air propellers, and they found themselves with no sure starting point. They discussed and argued the question, sometimes heatedly, until they concluded that an aeronautical propeller is essentially a wing rotating in the vertical plane. On that basis, they used data from more wind tunnel tests to design their propellers. The finished blades were just over eight feet long, made of three laminations of glued spruce.
The Wrights decided on twin "pusher" propellers (counter-rotating to cancel torque), which would act on a greater quantity of air than a single relatively slow propeller and not disturb airflow over the leading edge of the wings.
Wilbur made a March 1903 entry in his notebook indicating the prototype propeller was 66% efficient. Modern wind tunnel tests on reproduction 1903 propellers show they were more than 75% efficient under the conditions of the first flights, "a remarkable feat", and actually had a peak efficiency of 82%. The Wrights wrote to several engine manufacturers, but none could meet their need for a sufficiently lightweight powerplant. They turned to their shop mechanic, Charlie Taylor, who built an engine in just six weeks in close consultation with the brothers.
First powered flight
In camp at Kill Devil Hills, the Wrights endured weeks of delays caused by broken propeller shafts during engine tests. After the shafts were replaced (requiring two trips back to Dayton), Wilbur won a coin toss and made a three-second flight attempt on December 14, 1903, stalling after takeoff and causing minor damage to the Flyer. Because December 13, 1903, was a Sunday, the brothers did not make any attempts that day, even though the weather was good, so their first powered test flight happened on the 121st anniversary of the first hot air balloon test flight that the Montgolfier brothers had made on December 14, 1782.
In a message to their family, Wilbur referred to the trial as having "only partial success", stating "the power is ample, and but for a trifling error due to lack of experience with this machine and this method of starting, the machine would undoubtedly have flown beautifully."
Following repairs, the Wrights finally took to the air on December 17, 1903, making two flights each from level ground into a freezing headwind gusting to 27 miles per hour (43 km/h). The first flight, by Orville at 10:35 am, of 120 feet (37 m) in 12 seconds, at a speed of only 6.8 miles per hour (10.9 km/h) over the ground, was recorded in a famous photograph. The next two flights covered approximately 175 and 200 feet (53 and 61 m), by Wilbur and Orville, respectively. Their altitude was about 10 feet (3.0 m) above the ground.
Five people witnessed the flights: Adam Etheridge, John T. Daniels (who snapped the famous "first flight" photo using Orville's pre-positioned camera), and Will Dough, all of the U.S. government coastal lifesaving crew; area businessman W. C. Brinkley; and Johnny Moore, a teenaged boy who lived in the area. After the men hauled the Flyer back from its fourth flight, a powerful gust of wind flipped it over several times, despite the crew's attempt to hold it down. Severely damaged, the Wright Flyer never flew again. The brothers shipped the airplane home, and years later Orville restored it, lending it to several U.S. locations for display, then to the Science Museum in London , before it was finally installed in 1948 in the Smithsonian Institution, its current residence.